View Single Post
Old 04-18-2013, 08:28 AM   #5
jwalters OP
Farkle Proliferator
jwalters's Avatar
Joined: Jun 2005
Location: Little Marais, MN
Oddometer: 2,344
I've cleaned and replaced the pilot jet with a brand new one. It's not it. Bikebandit doesn't have the seal. That's what I was originally asking for it on this thread because I was only able to find one on Ebay (and I bought it) but I can't find the right side seal anywhere.

Where exactly do you take a crank seal to have made?

EDIT: I've also checked the rotary intake timing and spark timing, as that can be a cuplit on these bikes, but to no avail.

Originally Posted by buls4evr View Post
Your symptoms say to look for a plugged pilot jet before you get too crazy. Not flowing fuel at idle normally is classic pilot jet failure behavior..... Just buy a new one.... Then if you need a seal try BikeBandit. Suzuki might still have those or take an old one in and have one made. I would still pump the engine though and check for crank/rod play as that engine is old.
Minnesota North Shore Shindig 10-13 September 2015 -- Finland, MN

Proliferator of Farkles of Mass Percussion

jwalters screwed with this post 04-18-2013 at 08:40 AM
jwalters is offline   Reply With Quote